Camino Blister Prevention: 10 Tools & Tips

The Ultimate Guide to Walking the Camino Blister Free Landscape Banner

Originally published on Camino Adventures: What’s the most common injury experienced on the Camino? Without doubt, foot blisters! In this article, I'll share with you my top 10 Camino blister prevention and treatment tools and tips that will take you far.

Camino blister prevention & treatment

Walking day after day - with foot blisters. They:

  • Are painful
  • Take precious time, effort and skill to look after
  • Make you walk differently and that can stir up other aches and pains
  • Can get infected, and wind you up in hospital

Not only that, they take mental effort thinking and worrying about them. They put your long walk on the Camino at risk, physically and mentally.

Whether it’s your first time, or you’re returning and hoping your feet can complete the journey less battered and bruised, you’ll probably do some blister research before you leave. Thankfully, there is an enormous amount of blister advice and opinion online. Problem is, much of it conflicting and it can leave you more confused than ever.

I’ve been there – and I’m a podiatrist! It can be tricky sorting fact from fiction when it comes to foot blisters. Out of necessity for my own blister-prone feet, I’ve researched widely and now specialise in helping active people manage blisters properly.

In the last few months I’ve noticed an influx of enquiries from people from Australia and beyond seeking advice on how to prepare their feet for the Camino de Santiago. So I got in touch with Leslie and he has kindly invited me to share a few pearls of wisdom with you along the lines of Camino blister prevention and treatment.

blisters are the most common injury on the Camino. Learn how to perform adequate Camino blister prevention

Take these 10 blister tips on your Camino


Although it’s almost impossible to keep your feet bone-dry, your aim should be to keep them as dry as you reasonably can. Dry skin equals less friction, and that equals less blisters.

  • Without doubt, I always recommend moisture-wicking socks. Made from synthetic fibres and sometimes high-grade merino wool, they move moisture away from the skin. Don’t get socks with cotton in them. Cotton has the opposite effect – it keeps moisture trapped against your skin.
  • A simple change of socks half way through your day can make a big difference.
  • Unless your skin is very dry, too dry, don’t moisturise your skin. Moisturisers increase friction levels.


A blister is an injury initiated by a tear under the skin surface. This tear is caused by the skin stretching too much, which causes the connections between skin cells to fatigue. Fluid fills the torn area and it makes the skin bubble up, forming the blister roof.

So it makes sense to try and toughen the skin and make it more resistant to this stretching, called skin shear. The only way to toughen your skin is to expose your feet to the amount of walking you’ll be doing on the trail. That includes training in your chosen shoes and on similar terrain.

  • Well before the walk, decide on the footwear you’ll be wearing and get training in them. If you’re taking more than one pair, train in both.
  • Depending on your situation at home, training for the conditions of the Camino can be tricky. And putting the hours on your feet just as difficult with our busy lifestyles. One thing I can tell you is, most blisters become apparent in the first few days. So if you’re expecting trouble because you haven’t been able to train, ease into it for the first week.
  • Some people like soaking their feet in witch hazel, surgical spirit, white vinegar, cold black tea or other concoctions thinking they toughen the skin. Although these astringents don’t toughen the skin, they do dry it out and that’s still a good thing, at least in the short term.


This is entirely personal preference. Either way, they must fit well. This starts with getting the length right. Ever heard of the rule of thumb? When it comes to fitting footwear, this refers to having the width of your thumb between the end of your longest toe and the end of the shoe’s upper. Any less and there’s not enough room for your toes.learn how to prevent and treat blisters, whether you wear boots or athletic shoesUse the rule of thumb to ensure your shoes or boots have enough room for your toes. This walker had to resort to cutting the toebox out of her boots to relieve her toe blisters. Picture by S Lake.

There are three things you should consider in helping you make your decision.

  • Comfort is (almost) Let this be a very big factor in choosing the footwear you’ll take with you. Studies show that how comfortable they feel when you first put them on and walk around is a good sign that shoe or boot is good for you.
  • Water-proofed boots intuitively sound like a good idea. And they can be a great idea if there is light rain and wet grass to walk through. But no boot is entirely water-proof. Think about water run-off from your legs, running down your socks and straight into the boot. And think about the eyelets (the holes your laces go through) – they’re entry points for water in saturating situations. Additionally, the more waterproof the upper of the boot is, generally, the less water is able to evaporate through from inside to out. This means your perspiration is trapped within. If you have very sweaty feet, be prepared to stop to air your feet and change socks more often.
  • Athletic shoes with their mesh uppers allow sweat to evaporate out. But they put up next to no resistance to water getting in from the outside. They’ll allow more sand and dust into your shoe too, and that can be a problem on some terrains of the Camino. If you choose this kind of shoe, be prepared to stop to tip any foreign particles out. Additionally, athletic shoes won’t provide as much support to your ankle compared to a boot.


Your feet will swell. They will probably swell so much as to mean the shoes that fitted you perfectly on day one will be too tight at some point later on. The issue will be width rather than length. This will mostly be an issue for toe blisters and edge blisters on the side of your forefoot. So what’s the solution?

  • Be mindful of this when you are selecting your footwear. Choose a shoe that has a little bit more to offer in width than you would normally need. Some people go up a size to get that width and that usually works out fine, as long as you use your laces to keep a snug fit early on. Some people find they need to go up two or more sizes to get the width they need – I’m not so comfortable in recommending this. If you’re able to, just get a wider fitting. Or take two different pairs.
  • Elevate your feet when you’re resting on the track or once you’ve finished for the day. Give that swelling every chance to go down as much as possible.


The key to a blister-free Camino journey is in blister prevention. And your last chance for blister prevention is the hot-spot stage. A hot-spot is a brief and subtle sensation of rubbing, irritation or warmth. If you feel a sting, you’re too late – a blister is on the way. You need to stop and act immediately. Take your shoe off and take a look – what’s going on in there? Tip any sand out, check your sock isn’t bunched up or threadbare, firm up your laces … it all depends what’s going on. Place a piece of tape over your hot-spot, or your favourite greasy lubricant or whatever you have planned for this blister location.


Everyone takes tape, don’t they? Something to stick over a hot-spot? Many times, that’s all it takes. The type of tape is entirely up to you. Test several when training.

  • Fixomull is a thin and flexible one, good for going around fiddly bits like toes, and it has a strong adhesive.
  • Paper tape is thin but not as stretchy and doesn’t stick quite as well as Fixomull.
  • You could try one of the kinesio tapes like RockTape or KinesioTex tape. They’re a bit thicker yet very flexible.
  • Rigid sports tapes can help but are tricky to apply to small fiddly areas like toes.
  • Then there’s moleskin and fleecyweb which are thicker again.
  • different types of tape for preventing blisters on the camino

From left to right: Fixomull Stretch, RockTape, KinesioTex, Leukoplast rigid tape, 3M surgical paper tape.

Whatever you do, don’t stick any of these tapes directly over your blister – because it will rip the roof off your blister when you go to remove the tape. If you have a blister, in the majority of cases, you’ll need to use an island dressing. An island dressing has a non-adherent pad in the middle and adhesive all the way around to secure it in place and keep the germs out. There is another type of blister dressing called a hydrocolloid dressing. Compeed is a popular one on the Camino. You’ll hear a lot of conflicting advice about this dressing – some love it, some hate it. I’ll tell you why, next.


Not all blisters are created equal. In fact, there are three types of blisters, each requiring a different type of treatment. You have to match the right treatment to the right blister, or you’ll turn a bad situation into a terrible one. The three types of blisters are based on the integrity of the blister roof:

  1. Roof intact
  2. Roof torn
  3. Deroofed
5 stages of blister development

The 5 stages of the blister process: The first two are your opportunities for blister prevention. The remaining three are where you’ll be performing blister treatment.

The most common mistake I see is the incorrect use of Compeed, or any other hydrocolloid dressing. Never use Compeed on an intact or torn blister – it will simply rip your blister roof off when you go to remove the dressing. And don’t use Compeed expecting it to prevent blisters – it won’t. You can still blister under the Compeed and that is not fun! Compeed should only ever be used on a deroofed blister. The weepiness of the raw blister base prevents the dressing from sticking to it. Plus it provides the perfect moist environment for skin healing.

The Blister Treatment Blueprint outlines the step-by-step treatment for each type of blister. You can download it free here.


In the ideal world, you wouldn’t pop a blister. You’d leave the skin intact so there’s no possibility of it getting infected. And you’d take it easy for a week or so and let it heal in due course. On the Camino, that’s probably not going to happen, and so puncturing and draining your blister can be a good idea. But you have to consider your situation carefully. The benefits will only outweigh the risks if you know how to treat a torn blister properly, and have the equipment required to do the job. Use a sterile piercing implement (I use a scalpel blade), a clean technique (have you got your antibacterial hand gel) and antiseptic liquid over your blister (to prevent infection).


Although you’ll do your best to prevent blisters from happening in the first place, anticipate blister trouble. Have a fully-stocked blister kit with enough tape, dressings, antiseptic and everything you’ll need for dealing with hot-spots and treating all three types of blisters. On top of the general blister kit gear, consider a few items that will give you advanced blister management capabilities. Consider taking thick orthopaedic felt, ENGO Patches, silicone gel toe sleeves or caps and sterile scalpel blades.Camino blister kit contentsThick orthopedic felt for donut pads; ENGO Patches for reducing friction levels between your sock and the shoe or insole; silicone gel toe covers for absorbing shear; and sterile scalpel blade for lancing blisters.


The Camino is neither the time nor place to start experimenting. Sure, you may have to try something new if you find yourself in the worst possible situation with blisters. But a better approach is to experiment in the weeks and months preceding your trip. This is how you build a rock-solid blister plan. Take into account your blister history – these are the blisters you can expect to be troubled with on your walk. Start on day one with your tried and trusted preventive strategy in place. And keep a little something extra up your sleeve for these blister locations, just in case. In addition, you’ll need a plan for the blisters you’ve never had before. Because let’s face it, unexpected things happen out there.


Don’t let foot blisters spoil your Camino adventure. Do your best to prepare well before you leave. Prepare your feet, your blister kit, your blister plan. Don’t ignore hot-spots. And master the art of blister treatment.

To find out more, download the Ultimate Guide To Walking the Camino Blister-Free.

Rebecca Rushton BSc(Pod)

Comments & Questions

    1 out of ...

    Sign up right now and you’ll become a VIP subscriber, with immediate access to the Vaseline report.

    Subscribe to the newsletter